2024 GMC Canyon recalls, problems & safety ratings
NHTSA lists 3 recalls for the 2024 GMC Canyon and 207 owner complaints. The most-reported problem areas are exterior lighting (159), electrical system (26), service brakes (14). It earned a 4-star overall NHTSA safety rating. EPA-rated fuel economy is 19–20 mpg combined, depending on configuration.
The 2024 ranks #11 of 13 Canyon model years for fewest complaints (2012–2026), with more complaints than the average year (84). It has 3 recalls vs. an average of 2.2 per model year.
Recalls 3
Every recall NHTSA lists for the 2024 GMC Canyon. Not every recall applies to every vehicle, so check your VIN. Recall repairs are free at a franchised dealer.
Air bags · frontal · passenger side · inflator module
Problem: General Motors, LLC (GM) is recalling certain 2024–2026 GMC Canyon AT4X AEV vehicles. Incorrect sensing and diagnostic module (SDM) software may cause a second stage passenger air bag deployment when only a first stage is intended. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 208, “Occupant Crash Protection."
Risk: An air bag that deploys improperly increases the risk of injury in a crash.
Fix: Dealers will update the SDM software, free of charge. Owner notification letters were mailed January 30, 2026. Owners may contact GMC customer service at 1-800-462-8782. GM's number for this recall is N252533510. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 11, 2025.
Exterior lighting · headlights
Problem: General Motors, LLC (GM) is recalling certain 2024 GMC Canyon vehicles. The headlights may flicker while driving and while the vehicle is in park. As such, these vehicles fail to comply with the requirements of Federal Motor Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Headlights flickering can reduce visibility, increasing the risk of a crash.
Fix: Dealers will replace a module in the headlight, free of charge. Owner notification letters were mailed October 10, 2024. Owners can contact GMC customer service at 1-800-462-8782. GM's number for this recall is N242468880.
Fuel system, gasoline · storage · tank assembly
Problem: General Motors, LLC (GM) is recalling certain 2024 Chevrolet Colorado and GMC Canyon vehicles. The lock ring that secures the fuel pump to the fuel tank assembly may not have been fully locked during assembly, which can result in a fuel leak during a crash.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Fix: Dealers will inspect and fully lock the fuel tank lock ring as necessary, free of charge. Owner notification letters are expected to be mailed August 13, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC Customer Call Center at (888) 988-7267. GM's number for this recall is N242451330.
Common problems
From complaints owners filed with NHTSA. Complaints aren't verified, but patterns across hundreds of owners point to known weak spots.
Most-reported problem areas
By the numbers
Recent owner reports
2024 GM Canyon bought brand new in December 2024, now has 24,700 miles and the front brake pads are down to 2% per the GMC dealership service department. Premature brake wear, and GM is refusing to pay for it.
I purchased my truck with 5 miles on the speedometer in Anchorage AK 4/7/2024. In May 2024, the engine idled rough and transmission shifted hard, I was told me it was normal, and I would have to wait 2 yrs to make a transmission appointment. In June 2024 approaching a green light, approximately 35 mph, the brakes locked, I had no control over the steering and it left a 5 foot…
Vehicle alerted driver that ECS and. Rake assist was needed and disabled abs and forward collision while lighting up multiple warning lights on dashboard. Lights eventually turned off leaving a check engine light on. Multiple codes pulled from system using obd2 reader. Communication bus B offline and U0074, U0151, U0447,U0452 all at same time.
Safety ratings
2024 GMC Canyon PU/CC 4WD
2024 GMC Canyon PU/CC RWD
Fuel economy
EPA ratings for common configurations of the 2024 GMC Canyon.
Canyon 2WD
Auto 8-spd · 4 cyl · 2.7 L · Turbo
Regular
Canyon 4WD
Auto 8-spd · 4 cyl · 2.7 L · Turbo
Regular
Other model years
Questions
How many recalls does the 2024 GMC Canyon have?
NHTSA lists 3 recalls for the 2024 GMC Canyon, most recently for air bags · frontal · passenger side · inflator module (12/11/2025). Recall repairs are free at a franchised dealer. Enter your VIN to check whether a recall applies to your vehicle.
What are the most common problems with the 2024 GMC Canyon?
Based on 207 owner complaints filed with NHTSA, the most-reported areas are exterior lighting (159), electrical system (26), service brakes (14).
Is the 2024 GMC Canyon safe?
The 2024 GMC Canyon earned a 4-star overall rating in NHTSA's 5-star safety ratings.
Is the 2024 a good year for the GMC Canyon?
The 2024 ranks #11 of 13 Canyon model years for fewest complaints (2012–2026), with more complaints than the average year (84). It has 3 recalls vs. an average of 2.2 per model year.
What gas mileage does the 2024 GMC Canyon get?
EPA ratings for the 2024 GMC Canyon range from 19 to 20 mpg combined, depending on configuration.
Own a 2024 GMC Canyon in South Carolina?
Our mobile mechanics diagnose and fix the problems above at your home, office or fleet lot in Lexington, Columbia and the Midlands, with dealer-grade scan tools.
Related vehicles
Sources: NHTSA recalls, complaints and 5-Star Safety Ratings APIs; EPA fueleconomy.gov. Data retrieved November 2, 2026. NHTSA model names used: CANYON, Canyon.