2024 Hyundai Kona recalls, problems & safety ratings
NHTSA lists 4 recalls for the 2024 Hyundai Kona and 53 owner complaints. The most-reported problem areas are electrical system (31), engine (9), service brakes (7). It earned a 4-star overall NHTSA safety rating. EPA-rated fuel economy is 27–28 mpg combined, depending on configuration.
The 2024 ranks #3 of 9 Kona model years for fewest complaints (2018–2026), with fewer complaints than the average year (93). It has 4 recalls vs. an average of 1.4 per model year.
Recalls 4
Every recall NHTSA lists for the 2024 Hyundai Kona. Not every recall applies to every vehicle, so check your VIN. Recall repairs are free at a franchised dealer.
Seat belts · rear/other · buckle assembly
Problem: Hyundai Motor America (Hyundai) is recalling certain 2024-2025 Kona Electric and 2024-2026 Kona vehicles. The seat belt buckle in the rear center seat may fail to properly restrain an occupant during a crash.
Risk: A seat belt buckle that fails to properly restrain an occupant in a crash increases the risk of injury.
Fix: Passengers are advised not to use the rear center seat until the recall remedy is performed. Dealers will replace the seat belt buckle assembly, free of charge. Owner notification letters were mailed September 2, 2026. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 306. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 15, 2026.
Engine and engine cooling · exhaust system · emission control · gas recirculation valve (egr valve)
Problem: Hyundai Motor America (Hyundai) is recalling certain 2024 Elantra, Venue, and Kona vehicles. An electrical short circuit may occur in the exhaust gas recirculation (EGR) valve assembly, which can result in a loss of drive power.
Risk: A loss of drive power increases the risk of a crash.
Fix: Dealers will replace the exhaust gas recirculation valve assembly, free of charge. Owner notification letters were mailed June 28, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 260.
Electrical system · 12v/24v/48v battery · cables
Problem: Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The 12-Volt battery cables may chafe against the engine control module bracket and short circuit during a crash.
Risk: A short circuit increases the risk of an engine compartment fire.
Fix: Dealers will install sheathing over the wiring, free of charge. Owner notification letters were mailed February 22, 2024. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 252.
Seat belts · rear/other · retractor
Problem: Hyundai Motor America (Hyundai) is recalling certain 2024 Kona vehicles. The seat belt assemblies in the right and left rear seats may not function properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 208, "Occupation Crash Protection" and 209, "Seat Belt Assemblies."
Risk: A seat belt that does not function properly may not adequately restrain an occupant in a crash, increasing the risk of injury.
Fix: Dealers will inspect and replace the seat belt retractor as necessary, free of charge. Owner notification letters were mailed November 21, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 250.
Common problems
From complaints owners filed with NHTSA. Complaints aren't verified, but patterns across hundreds of owners point to known weak spots.
Most-reported problem areas
By the numbers
Recent owner reports
I purchased a new 2024 Hyundai Kona in September 2023 and followed its scheduled maintenance program. By August 12, 2026, I had noticed mild, intermittent excessive brake-pedal travel, especially at low speeds. I reported it to the dealer that day; September 14 was their earliest available appointment. By September 14, the pedal drop was more pronounced and frequent at low spe…
sitting at a light, pressing the accelerator, the engine remaining on but the vehicle not accelerating.
See attached document for complaint.
Safety ratings
2024 Hyundai Kona SUV AWD
2024 Hyundai Kona SUV FWD
Fuel economy
EPA ratings for common configurations of the 2024 Hyundai Kona.
Kona AWD
Auto (AV-S1) · 4 cyl · 2.0 L
Regular
Kona AWD
Auto (AV-S1) · 4 cyl · 2.0 L · Stop-Start
Regular
Kona Electric Long Range
Auto (A1)
Electricity
Other model years
Questions
How many recalls does the 2024 Hyundai Kona have?
NHTSA lists 4 recalls for the 2024 Hyundai Kona, most recently for seat belts · rear/other · buckle assembly (07/15/2026). Recall repairs are free at a franchised dealer. Enter your VIN to check whether a recall applies to your vehicle.
What are the most common problems with the 2024 Hyundai Kona?
Based on 53 owner complaints filed with NHTSA, the most-reported areas are electrical system (31), engine (9), service brakes (7).
Is the 2024 Hyundai Kona safe?
The 2024 Hyundai Kona earned a 4-star overall rating in NHTSA's 5-star safety ratings.
Is the 2024 a good year for the Hyundai Kona?
The 2024 ranks #3 of 9 Kona model years for fewest complaints (2018–2026), with fewer complaints than the average year (93). It has 4 recalls vs. an average of 1.4 per model year.
What gas mileage does the 2024 Hyundai Kona get?
EPA ratings for the 2024 Hyundai Kona range from 27 to 28 mpg combined, depending on configuration.
Own a 2024 Hyundai Kona in South Carolina?
Our mobile mechanics diagnose and fix the problems above at your home, office or fleet lot in Lexington, Columbia and the Midlands, with dealer-grade scan tools.
Related vehicles
Sources: NHTSA recalls, complaints and 5-Star Safety Ratings APIs; EPA fueleconomy.gov. Data retrieved November 2, 2026. NHTSA model names used: KONA, Kona.